BRITAIN'S aviation regulator has banned the use over British seas of helicopters similar to the one that ditched off Shetland this week.
The Civil Aviation Authority (CCA) order applies to all Super Puma EC225s and its older variant AS332, except those involved in life-saving operations.
It has emerged the EC225 that came down in the sea while flying workers from Aberdeen to the West Phoenix drilling rig had gearbox and emergency lubrication problems similar to that which caused another Super Puma to make an emergency landing four months ago.
Eurocopter has admitted extra maintenance checks ordered after an EC225 ditched in the North Sea in May failed to prevent a similar mechanical failing on the same model of aircraft on Monday.
The helicopter manufacturer has now ordered more frequent and thorough checks.
But it faced criticism from pilots union Balpa, which said the enhanced safety regime put in place in collaboration with the European Aviation Safety Agency (EASA) earlier this year had not been sufficient.
Now the CAA has stepped in to impose restrictions over flying saying: "This decision reflects the challenging conditions that UK offshore flying presents."
The CAA said it had prohibited flying of affected helicopters on all "open sea areas" around Britain.
The EASA also issued a directive increasing the frequency of checks of affected helicopters.
CHC Helicopter, the operator of the aircraft involved in the latest incident, has suspended all flights of the model, and two further operators, Bond and Bristow, have followed suit.
Balpa said there was growing concern among helicopter pilots about the Super Puma and for the oil and gas workers who regularly fly in it.
"We question what EASA and Eurocopter have done to ensure the fault identified in May's incident has been rectified on all helicopters of this type.
"Whatever action has been put in place has clearly not been sufficient if the AAIB's initial investigation proves to be correct," Balpa said.
The EC225 and the AS332, have been involved in a series of incidents that have led to fatalities and grounding of fleets.
In April 2009, 16 people died when an AS332 L2 Super Puma returning to Aberdeen from the BP Miller platform plunged into the sea after gearbox failure.
That happened six weeks after BP suspended flights involving EC225s after a Super Puma with 18 on board came down 550 yards from a company rig off the coast of Aberdeen, and Bond moved to ground other EC225s.
An Emergency Airworthiness Directive was later issued on the EC225 and the AS332 over concerns about the fairing gutter, which protects the intermediate gearbox.
An AAIB report into the latest incident – involving a CHS -operated EC225 with 19 people on board – revealed a crack on a gear shaft.
The AAIB said the problems were with a "bevel gear vertical shaft", the same type that failed when another EC225 was forced to carry out an emergency landing in the North Sea, with 12 passengers and two crew aboard, 20 miles off Aberdeen in May. All were rescued with only two receiving minor injuries.
Why are you making commenting on The Herald only available to subscribers?
It should have been a safe space for informed debate, somewhere for readers to discuss issues around the biggest stories of the day, but all too often the below the line comments on most websites have become bogged down by off-topic discussions and abuse.
heraldscotland.com is tackling this problem by allowing only subscribers to comment.
We are doing this to improve the experience for our loyal readers and we believe it will reduce the ability of trolls and troublemakers, who occasionally find their way onto our site, to abuse our journalists and readers. We also hope it will help the comments section fulfil its promise as a part of Scotland's conversation with itself.
We are lucky at The Herald. We are read by an informed, educated readership who can add their knowledge and insights to our stories.
That is invaluable.
We are making the subscriber-only change to support our valued readers, who tell us they don't want the site cluttered up with irrelevant comments, untruths and abuse.
In the past, the journalist’s job was to collect and distribute information to the audience. Technology means that readers can shape a discussion. We look forward to hearing from you on heraldscotland.com
Comments & Moderation
Readers’ comments: You are personally liable for the content of any comments you upload to this website, so please act responsibly. We do not pre-moderate or monitor readers’ comments appearing on our websites, but we do post-moderate in response to complaints we receive or otherwise when a potential problem comes to our attention. You can make a complaint by using the ‘report this post’ link . We may then apply our discretion under the user terms to amend or delete comments.
Post moderation is undertaken full-time 9am-6pm on weekdays, and on a part-time basis outwith those hours.
Read the rules hereComments are closed on this article